攪拌車空氣濾清器這樣保養才是正確的
空氣濾清器是攪拌車上的一個重要部件，主要是用于進入發動機的空氣過濾，有了空氣濾清器的作用，才能保證進入車輛發動機的空氣是清潔的，足量的?？諝鉃V清器如此重要，在日常使用過程中保養是必不可少的，那么空氣濾清器該如何保養呢？下面全自動攪拌車廠家為您講講。
The air filter is an important part of the mixer, which is mainly used to filter the air entering the engine. Only with the function of the air filter can the air entering the engine of the vehicle be clean and sufficient. The air filter is so important that maintenance is essential in daily use. How to maintain the air filter? Next, the manufacturer of the automatic mixer will tell you something.
一、空氣濾清器的清理要有序：
1、 Clean the air filter orderly:
空氣濾清器清理順序一般是：
The cleaning sequence of air filter is generally as follows:
1.取下濾芯，用干凈的布或者是橡皮塞堵住濾芯兩端，用軟毛刷沿著遮縫方向刷去濾芯表面的灰塵，敲打?yàn)V芯端面，是灰塵脫落。也可使用壓縮空氣從濾芯由內向外吹氣，吹去粘附在濾芯表面的灰塵，清理時禁止使用液體清洗，以防止濾芯粘附灰塵，造成堵塞。
1. Remove the filter element, block both ends of the filter element with a clean cloth or rubber stopper, brush the dust on the filter element surface along the seam covering direction with a soft bristle brush, and knock the end face of the filter element to remove the dust. Compressed air can also be used to blow air from the inside to the outside of the filter element to remove the dust adhering to the surface of the filter element. Liquid cleaning is prohibited during cleaning to prevent the filter element from adhering to dust and causing blockage.
2.檢查主濾芯是否有破損，上下端面是否翹曲不平；檢查主濾芯橡膠密封圈是否破損；檢查主濾芯內側是否有灰塵，如果有上述任一問題，就需要更換主濾芯。
2. Check whether the main filter element is damaged and whether the upper and lower end faces are warped; Check whether the rubber sealing ring of the main filter element is damaged; Check whether there is dust inside the main filter element. If there is any of the above problems, replace the main filter element.
3.使用強光手電筒檢查濾芯是否破損，檢查時不要拆下濾芯，若濾芯有破損應立即更換，在清理濾芯殼體的過程中，要使用干凈抹布將殼體內壁擦拭干凈，并檢查排塵閥是否正常排塵。
3. Use a strong light flashlight to check whether the filter element is damaged. Do not remove the safety filter element during the inspection. If the safety filter element is damaged, replace it immediately. In the process of cleaning the filter element shell, use a clean rag to clean the inner wall of the shell, and check whether the dust valve can discharge dust normally.
二、空氣濾清器也不能清理太過頻繁
2、 The air filter cannot be cleaned too frequently
假如空氣濾清器清理太過頻繁，那么濾芯的過濾能力就得不到充分的額發揮，這樣不僅使得進入發動機的灰塵數量增多，造成發動機異常磨損，還會造成濾芯的早期損壞。濾芯在每次清理后，其容灰的能力就會降低20%-40%，隨著清理次數的增加，濾芯的容灰量就會逐漸降低，當濾芯清理5次以后，容灰量就基本沒有了，此時就必須更換空濾了。
If the air filter is cleaned too frequently, the filtering capacity of the filter element will not be fully utilized. This will not only increase the amount of dust entering the engine, cause abnormal wear of the engine, but also cause early damage to the filter element. After each cleaning, the dust capacity of the filter element will decrease by 20% - 40%. With the increase of cleaning times, the dust capacity of the filter element will gradually decrease. When the filter element is cleaned for 5 times, the dust capacity will almost disappear. At this time, the air filter must be replaced.
空氣濾清器是攪拌車配件的一種，雖然不算昂貴，但是如果損壞就會嚴重影響發動機的正常工作，因此建議駕駛工程車的朋友一定要定期的清理空氣濾清器。關注我們http://www.jbckj.cn，了解更多相關事項！
The air filter is a part of the mixer truck. Although it is not expensive, it will seriously affect the normal operation of the engine if it is damaged. Therefore, it is recommended that friends driving engineering vehicles must clean the air filter regularly. Follow us http://www.jbckj.cn , learn more about it!
