自動攪拌車問題解答或許有你要了解的！
1、駕駛混凝土自動攪拌車應注意什么?
1. What should you pay attention to when driving an automatic concrete mixer?
駕駛自動混凝土攪拌機，為經驗豐富的駕駛員，具備駕駛的一般知識。這里要提醒的是，因為混凝土是流態的，車輛行駛時遇彎道，必須降低速度，以免混凝土不穩定產生的離心力使車輛不穩!
Driving the automatic concrete mixer is an experienced driver with general knowledge of safe driving. It should be reminded here that because the concrete is in a fluid state, when the vehicle is driving in a curve, the speed must be reduced to avoid the centrifugal force generated by the instability of the concrete making the vehicle unstable!
2、混凝土自動攪拌車多裝混凝土有哪些影響?
2. What are the effects of loading more concrete in automatic concrete mixer?
9方以下的混凝土自動攪拌車多裝混凝土，在爬坡過程中會發生漏灑情況，12方攪拌車多裝混凝土，攪拌會分層，混凝土砂率將偏低，石粒尺寸過大，到工地泵送石子多。
If the automatic concrete mixer below 9 m3 loads more concrete, there will be leakage during the climbing process. If the 12 m3 mixer loads more concrete, the mixing will be layered, the concrete sand rate will be low, the stone particle size is too large, and there will be too many stones pumped to the construction site.
3、新的混凝土自動攪拌車一般開幾年后容易出問題。
3. The new automatic concrete mixer is generally prone to problems after driving for a few years.
一般來說，拉干料一般5年，拉濕料一般是7年。故障問題多發生在使用三年后，混凝土自動攪拌車容易出現問題，因此建議時常對設備進行保養，保養維護對延長混凝土自動攪拌車有很大作用。
Generally speaking, it takes 5 years to pull dry materials and 7 years to pull wet materials. The failures often occur after three years of use, and the automatic concrete mixer is prone to problems. Therefore, it is recommended to maintain the equipment from time to time, which plays a great role in prolonging the automatic concrete mixer.
4、混凝土凝固在混凝土自動攪拌車里怎么辦?
4. What if the concrete solidifies in the automatic concrete mixer?
固化后，混凝土的主要成分為硅酸二鈣和硅酸三鈣。理論上，鹽酸可以與之反應以去除其固體形狀。但在實際操作中，由于混合器的物料口很小，鹽酸的用量難以控制，鹽酸也可以與攪拌車罐體發生反應，因此操作難度很大。事實上，這種情況發生后，往往使用電焊或氣割切割罐體，
After curing, the main components of concrete are dicalcium silicate and tricalcium silicate. In theory, hydrochloric acid can react with it to remove its solid shape. However, in actual operation, due to the small material port of the mixer, the amount of hydrochloric acid is difficult to control, and hydrochloric acid can also react with the tank of the mixer, so the operation is very difficult. In fact, after this happens, the can body is often cut by electric welding or gas cutting,
然后將凝固的混凝土進行破碎時。
When the solidified concrete is then broken.
5、混凝土自動攪拌車上裝指的是什么?
5. What does loading on automatic concrete mixer refer to?
攪拌車上裝是指底盤擋泥板以外的東西，包括混合罐本體和支架、進出料斗、液壓系統和減速機、水箱和管路、操作連桿機構等。
The upper loading of mixer truck refers to the things other than the chassis fender, including the mixing tank body and support, inlet and outlet hopper, hydraulic system and reducer, water tank and pipeline, operating linkage, etc.
6、普通混凝土自動攪拌車的液壓系統是國產的還是進口的?
6. Is the hydraulic system of ordinary concrete automatic mixer made in China or imported?
根據車輛的尺寸和客戶的需要，一般6方以下制造商配備國內系統(可選進口)，6方以上標配是進口系統。
According to the size of the vehicle and the needs of customers, manufacturers below 6 square meters are generally equipped with domestic systems (optional import), and the standard configuration above 6 square meters is imported systems.
7、小方量攪拌車的液壓泵是選擇定量泵還是變量泵?
7. Does the hydraulic pump of small volume mixer choose quantitative pump or variable pump?
液壓泵是攪拌車的主要部件。一般來說，攪拌車低于6方標準配置是定量泵，但建議客戶安裝變量泵。
Hydraulic pump is the main component of mixer truck. Generally speaking, the standard configuration of mixer truck lower than 6 square meters is quantitative pump, but it is recommended that customers install variable displacement pump.
8、攪拌機的焊接工藝是什么?
8. What is the welding process of mixer?
目前，一般廠家對整車焊接采用自動無縫焊接，環縫和縱縫采用自動無縫焊接。
At present, general manufacturers adopt automatic seamless welding for vehicle welding, and automatic seamless welding for circumferential seam and longitudinal seam.
9、混凝土自動攪拌車的付款方式是什么樣的?
9. What is the payment method of automatic concrete mixer?
混凝土自動攪拌車有多種付款方式，可以全額或分期付款。一般來說，廠家對全額付款會有一定的優惠，但分期付款沒有優惠，利息和銀行一樣。
There are many payment methods for automatic concrete mixer, which can be paid in full or in installments. Generally speaking, the manufacturer will have a certain discount for full payment, but there is no discount for installment payment, and the interest is the same as that of the bank.
10、如果混凝土自動攪拌車很難出料怎么辦?有沒有比加水更好的方法?
10. What if the automatic concrete mixer is difficult to discharge? Is there a better way than adding water?
如果是混凝土坍落度太小或混凝土強度太高，混凝土太黏不好下的原因，可根據施工要求適當調整混凝土，如果不總是好，應考慮葉片角度和出料口是否存在問題。想了解更多關于自動攪拌車知識,可以關注我們http://jbckj.cn
If the concrete slump is too small or the concrete strength is too high and the concrete is too sticky, the concrete can be adjusted appropriately according to the construction requirements. If it is not always good, consider whether there are problems with the blade angle and discharge outlet. If you want to know more about automatic mixer truck, you can pay attention to us http://jbckj.cn
下一篇：影響自上料攪拌機使用年限的是什么？上一篇：混凝土自上料攪拌車廠家哪家呢？
