混凝土攪拌機定期應該檢查的項目!
混凝土攪拌機定期應該檢查的項目：
Items that concrete mixer should check regularly:
對卷揚提升制動器進行檢查并作適當?shù)恼{(diào)整。
Check and adjust the hoist brake properly.
對水泵，節流閥進行檢查，是否有漏水現象。
Check the water pump and throttle valve for water leakage.
對開式齒輪進行檢查涂抹潤滑油并調整皮帶松緊。
Check the open gear, apply lubricating oil and adjust the belt tightness.
檢查混凝土攪拌機葉片，襯板的磨損情況，并酌情更換。
Check the abrasion condition of concrete mixer blades and lining plates, and replace them as appropriate.
為了使混凝土攪拌機能夠延長其使用壽命，混凝土攪拌機每星期應該檢查的項目：
In order to prolong the service life of concrete mixer, the items that concrete mixer should check every week are as follows:
檢查混凝土攪拌機鋼絲繩磨損情況并在其表明涂少許潤滑油，鋼絲繩磨損到一定程度后，應進行更換。
Check the wear of steel wire rope of concrete mixer and apply a little lubricating oil on it. After the steel wire rope is worn to a certain extent, it should be replaced.
檢查減速箱油面，油泵油量，檢查各潤滑部位的情況，往料斗滾輪軸承及滑輪軸承加注潤滑油。
Check the oil level of the gearbox, the oil quantity of the oil pump, check the condition of each lubricating part, and fill lubricating oil into the hopper roller bearing and pulley bearing.
供水裝置要保持清潔，以免堵塞，對吸水閥檢查清洗一次。檢查行程開關搖臂是否松動，如有松動應予必要調整。
The water supply device should be kept clean to avoid blockage. Check and clean the suction valve once. Check whether the rocker arm of the travel switch is loose, and adjust it if necessary.
檢查混凝土攪拌機葉片連接螺栓，支撐臂連接螺栓是否松動酌情調整，葉片與筒壁間的間隙較大間隙5mm并作必要的擰緊。
Check whether the connecting bolts of concrete mixer blades and support arm are loose, adjust them as appropriate, and the gap between blades and cylinder wall is larger, with a gap of 5mm, and tighten them as necessary.
檢查混凝土攪拌站電氣箱中接觸器觸頭情況。
Check the contact condition of the contactor in the electrical box of the concrete mixing station.
擰開放淤塞，檢查軸端密封，作必要的調整修理和更換。
Screw open the blockage, check the shaft end seal, make necessary adjustment, repair and replacement.
感謝您的閱讀，希望對您有所幫助，如您還有其他問題想了解，請點擊：中科自上料攪拌機http://jbckj.cn
Thank you for reading, hope to help you, if you have other questions, please click: Zhongke self feeding mixer http://jbckj.cn
