攪拌車空調使用與保養小知識
攪拌車空調使用與保養小知識您知道多少呢？下面就讓自上料攪拌車廠家為您講解一番。
How much do you know about the use and maintenance of mixer air conditioner? Let the self loading mixer manufacturer explain it for you.
一、定期更換攪拌車空調系統軟管
1、 Regularly replace the hose of air conditioning system of mixer truck
每一輛配備空調的攪拌車都具有高壓管和低壓管等若干根由膠管和鋁管組成的空調軟管，對于新車來說，攪拌車空調軟管不易因老化而出現泄漏制冷劑的現象，但是對于超過兩年的車來說，高溫、腐蝕、振動、撞擊等都容易縮短空調軟管的使用壽命。
Each air-conditioned mixer truck has several air-conditioning hoses composed of rubber pipes and aluminum pipes, such as high-pressure pipes and low-pressure pipes. For new vehicles, the air-conditioning hoses of the mixer truck are not easy to leak refrigerant due to aging. However, for vehicles more than two years old, high temperature, corrosion, vibration, impact and so on are easy to shorten the service life of the air-conditioning hoses.
因此，檢測攪拌車空調系統軟管的良好程度尤為重要，對攪拌車空調軟管應采取按期強制更換的原則，并定期檢查空調系統軟管和管接頭是否有油跡。如發現滲漏，應及時向汽車維修咨詢以及檢修更換。
Therefore, it is particularly important to check the good condition of the air-conditioning system hose of the mixer truck. The air-conditioning hose of the mixer truck should be replaced on schedule, and the hose and pipe joint of the air-conditioning system should be checked regularly for oil stains. In case of leakage, consult the automobile maintenance center for maintenance and replacement.
二：多面檢查攪拌車空調壓縮機部件
2： Inspect the air conditioning compressor components of the mixer truck in multiple ways
攪拌車空調壓縮機作為制冷劑流動的動力源在攪拌車空調系統中為重要。檢修空調時應注意其前部是否有異響，如有則應先對壓縮機進行維修，防止使用一段時間后再修，這樣很容易導致冷媒丟失。
As the power source of refrigerant flow, the air-conditioning compressor of mixer truck is very important in the air-conditioning system of mixer truck. When repairing the air conditioner, pay attention to whether there is abnormal noise at the front. If so, repair the compressor first to prevent it from being repaired after a period of use, which may easily lead to the loss of refrigerant.
同時還要檢查壓縮機皮帶是否良好。如果皮帶表面與皮帶輪槽接觸側面光亮，并且啟動攪拌車空調時有明顯的噪音，則說明皮帶打滑嚴重，需要更換皮帶和皮帶輪；如果皮帶過松則需要進行調整，否則會使攪拌車空調系統制冷不良。
At the same time, check whether the compressor belt is in good condition. If the surface of the belt and the contact side of the pulley groove are bright, and there is obvious noise when starting the air conditioner of the mixer truck, it means that the belt is seriously slipping, and the belt and pulley need to be replaced; If the belt is too loose, it needs to be adjusted, otherwise the air conditioning system of the mixer truck will have poor refrigeration.
三、注意清理冷凝器表面
3、 Pay attention to cleaning the condenser surface
冷凝器作為攪拌車空調系統的組成部分，往往由于不注意其表面的清理工作，而導致制冷效果下降。所以，在夏季使用空調時可以用水管對著冷凝器進行沖洗，因?yàn)閿嚢柢嚴淠鞅砻娴那鍧嵄阌谑篃崮苌l(fā)到外界去。
As a part of the air-conditioning system of the mixer truck, the condenser often fails to pay attention to the cleaning of its surface, resulting in a decline in the cooling effect. Therefore, when the air conditioner is used in summer, water pipes can be used to wash the condenser, because the cleaning of the condenser surface of the mixer truck is easy to dissipate heat energy to the outside.
另外，由于冷凝器安裝位置的特殊性，在其迎風一面往往會有許多灰塵、泥土、樹葉等異物，日積月累這些異物集覆過多就會導致冷凝器工作效果的降低，所以在維修中應對其表面進行清理，這樣可使攪拌車空調系統的制冷效果大大提高。
In addition, due to the particularity of the installation position of the condenser, there are often many foreign matters such as dust, soil, leaves on the windward side of the condenser. If these foreign matters accumulate over time, the working effect of the condenser will be reduced. Therefore, the surface of the condenser should be cleaned during maintenance, which can greatly improve the cooling effect of the air conditioning system of the mixer.
對于這個問題，我們從三個大方面來講解了，定期對攪拌車進行維護保養具有很好的作用，有更多了解就來我們網站http://jbckj.cn咨詢吧！
For this problem, we have explained it from three aspects. Regular maintenance of the mixer truck has a good effect. Come to our website for more information http://jbckj.cn Consult!
